Product ID:AUTOCOAT LV HARDENER FAST, 004098-NA
MSDS Date:11/01/1995
FSC:8010
NIIN:00N075011
MSDS Number: CFLSK

AKZO NOBEL COATINGS INC

5555 SPALDING DR
NORCROSS, GA 30092
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 770-441-8628

Cage: AKZNB

AKZO NOBEL COATINGS INC

NORCROSS, GA 30092 US

Telephone: 770-662-8464; 770-441-8628

Cage: AKZNB

1.5%; LD50 (ORAL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 1.9%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA) VP

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10-20%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM/200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOCYANIC ACID, HEXAMETHYLENE ESTER, POLYMERS; (ALIPHATIC

CAS: 28182-81-2

RTECS: NQ9170000

Fraction By Weight: 60-80%

OSHA PEL N/K

ACGIH TLV: 0.5 MG/M3 (MFR)

HEXANE, 1,6-DIISOCYANATO-; (HEXAMETHYLENEDIISOCYANATEMONO)

CAS: 822-06-0

RTECS: MO1740000

Fraction By Weight: <0.14%

OSHA PEL N/K

ACGIH TLV: 0.005 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

AROMATIC SOLVENT

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: 100 PPM (MFR)

2.1; LD50

CAS: 541-85-5

RTECS: MJ7350000

Fraction By Weight: 5-10%

OSHA PEL 25 PPM

ACGIH TLV: 25 PPM

1.1%; LD50

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

ISOCYANIC ACID, METHYLENE

CAS: 4098-71-9

RTECS: NQ9370000

Fraction By Weight: <0.13%

OSHA PEL 0.02 MG/M3 (MFR)

ACGIH TLV: 0.005 PPM

ANIMAL STUDIES TO CAUSE ADVERSE EFTS ON BLOOD &

RTECS: 9999999ZZ

CAUSING CARD ARRHYS. 2-BUTOXYETHYL ACETATE HAS BEEN

RTECS: 9999999ZZ

BLOOD & BLOOD-FORMING TISS. BUTYL ACETATE MAY BE

RTECS: 9999999ZZ

SYS SENSIT CAUSING BRONCH, BRONCHIAL SPASMS, PULM

RTECS: 9999999ZZ

DOSE-RELATED ADVERSE EFTS ON CNS, HEMATOPOIETIC

RTECS: 9999999ZZ

GLYCOL MONOBUTYL ETHER ACETATE (EGBEA) (EXTRACTED

RTECS: 9999999ZZ

MAXIMUM EXPOSURE AND USE PAINT SUIT, GOGGLES,

RTECS: 9999999ZZ

HEATING. REMOVE DECOMPOSITION PRODUCTS FORMED DURING

RTECS: 9999999ZZ

RESIST APRON, BOOTS/OTHER CLTHG IF NEEDED

RTECS: 9999999ZZ

SHOES AND LEATHER CAUSING DELAYED IRRITATION.

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: NASAL & RESP IRRIT,
DIZZ, WEAK, FATG, NAUS, HDCH, POSS UNCON, CHEM PNEUMIT, CNS DEPRESS
& EVEN ASPHY. SKIN: EXTRACTION OF NATRL OILS W/RSLTG DRY SKIN,
IRRIT, REDNESS & DERM. EYES: IRRIT, REDNESS, PAIN, BLURRED VISION,
SENSATION OF SEEING HALOS AROUND LIGHTS. INGEST: GI IRRIT, NAUS,
VOMIT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: & DIARR. CHRONIC: INHAL: DELAYED LUNG
DMG, KIDNEY, LIVER, & CARD DISORDERS, RED BLOOD CELL & LEUKOCYTE
DISORDERS WHICH MAY RSLT IN ANEMIA. SKIN: SENSIT MAY OCCUR. EYES:
EYE DMG. INGEST: KIDN EY & BLOOD SYS DMG. OTHER HLTH EFTS:
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING
CONTENTS MAY (SUP DAT)
Medical Cond Aggravated by Exposure:ISOCYANATE SENSITIZATION, SKIN
DISORDERS, EYE DISORDERS.

First Aid:INHALATION: MOVE TO FRESH AIR, GIVE ARTIFICIAL RESPIRATION IF
NECESSARY. SKIN: WASH WITH SOAP AND WATER, NOT SOLVENT. EYES: FLUSH
WITH WATER FOR AT LEAST 15 MINUTES, CONSULT MD. INGESTION: DRINK
ONE O R TWO GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING.
CONSULT MD OR POISON CONTROL CENTER IMMEDIATELY. TREAT
SYMPTOMATICALLY.

Flash Point:78.0F,25.6C
Lower Limits:0.9%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SHOULD BE USED TO COOL CONTAINERS EXPOSED TO
FIRE.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD, ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT (SUP DAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS, VENTILATE CONFINED AREA. DIKE TO REDUCE EXTENT OF
SPILL. REMOVE WITH INERT ABSORBENT USING NON-SPARKING TOOLS. IF
NECESSARY REPORT TO APPLICABLE GOVERNMENT AGENCY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE CONTRS OUT OF SUN & AWAY FROM
HEAT, SPARKS, & OPEN FLAMES. CLOSE ALL CONTRS AFTER EACH USE.
CONSULT NFPA & LOCAL CODES FOR ADDITIONAL STOR REQS.
Other Precautions:USE APPROVED BONDING AND GROUNDING PROCEDURES.
OBSERVE LABEL PRECAUTIONS. KEEP CLOSURES TIGHT AND CONTAINER
UPRIGHT TO PREVENT LEAKAGE. AVOID BREATHING SANDING DUST. DO NOT
WELD OR FLAME CUT ON EMPTY DRUM.

Respiratory Protection:ADEQ VENT IS REQUIRED. THIS PROD CONTAINS
ISOCYANATES. USE NIOSH APPRVD POS PRESS AIR SUPPLY RESP. SEE SFTY
EQUIP SUPPLIER FOR EVALUATION & REC. IN CASE WHERE NO MONITORING
FOR AIRBORNE CONTAMINANTS H AS BEEN CARRIED OUT, ASSUME (ING 15)
Ventilation:PROVIDE SUFFICIENT VENT TO KEEP VAP CONC BELOW GIVEN TLV
&/PEL. FOR BAKING FINISHES, EXHST VAPS EMITTED DURING (ING 16)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
USE MAX PROT EQUIP. COVER ALL EXPOSED AREAS. USE CHEMICAL (ING 17)
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING THE
WASHROOM. LAUNDER CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: SURF REQUIRES SPECIAL PREC. DURING EMER CNDTNS, OVEREXP TO
DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
OBTAIN MED ATTN. EFTS OF OVEREXP: BE HARMFUL/FATAL. RPTS HAVE AS
SOC RPTD & PRLNG OCCUP OVEREXP TO SOLVSW/PERM BRAIN & NERV SYS DMG.
AROMATIC HYDROCARBONS HAVE BEEN SHOWN IN (ING 9)

Boiling Pt:B.P. Text:>252F,>122C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.04
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:CLEAR LIQUID, ORGANIC ODOR
Percent Volatiles by Volume:35.0

Stability Indicator/Materials to Avoid:YES
ALKALIS, OXIDIZERS, ALKALI METALS, WATER, AMINES, NITRIC ACID, SODIUM
HYPOCHLORITE, METAL COMPOUNDS.
Stability Condition to Avoid:OPEN FLAME, HEAT, SPARKS, MOISTURE.
Hazardous Decomposition Products:OXIDES OF CARBON AND NITROGEN, VARIOUS
HYDROCARBONS, HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANATE (HDI).

Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
POLLUTION REQUIREMENTS. IN ADDITION, RAGS, SPRAY BOOTH FILTERS,
PAINT SUITS, EMPTY CANS, ETC, CONTAM W/PRODUCT MAY BE HAZARDOUS
WASTE. DETERMINE WHETHER CONTAMI NATED ITEMS ARE HAZARDOUS &
DISPOSE OF AS APPROP.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.